Fiat Panel Van 2009 onwards 25ltr/10kg underfloor Caratank kit designed for the X250 chassis and will suit vehicle with the exhaust exits towards the rear wheel.
Designed by Autogas 2000 Leisure Ltd in collaboration with CAD designers, the tank is secured by using purpose designed tank mounting cradle. The 25Ltr Caratank gives a 10kg working capacity and frees up the original gas locker box for other uses. This LPG tank setup kit is designed to be located in the centre of the vehicle just in front of the existing handbrake cable assembly, the Caratank used is 25ltr water capacity only on the euro 4. cut and folded to offer a mounting for any of our 200mm diameter gas tanks underfloor to the X250 chassis as used on many panel van conversions. Our underfloor tank mounting cradles are fully dipped and electroplated. By being electroplated, it goes inside the cradle to give the best corrosion protection possible. The design has been checked and an in-house certification is applied after confirmation from an engineering consultant to confirm that the cradle exceeds current recommendation for under floor tank mounting through mathematical calculations. The cradles are bolted through the chassis side so offer an easy fitting on pre-converted motor homes where a floor mounting would not be possible allowing the tank to lift straight in. This fixing also allows the tank to simply lifted into position during install and can in later life be simply removed for any service type of work that may be required.
Rubber insulation is also used between the tank and mounting frame to further protect the tank from corrosion build up between the two surfaces. Various tank regulators are available either direct, remote or crash sensing in the event of new vans that require to use the gas heating while driving (remote mounted regulator included in this kit).
A heat shield is provided to reflect heat from the vehicle exhaust but also acts as a suitable stone guard to protect the tank during normal use.
Included the is kit is the led switched gauge, which is usually mounted on the dashboard giving a clear reading of the gas amount from inside the van.
The filler included in the kit is the sill filler, which is attached just off the sill of the van. Other fillers can be provided, please contact us direct
Autogas 2000 Leisure Ltd recommend that the tank and associated fixing are further treated after install with suitable under-body stone guard spray on protection.
The kit comes complete with:
1x 25Ltr Caratank with valves & tank box
1x Pair of purpose designed tank mounting cradle
1x Rubber Strip (between tank and frame)
1x Fitting kit for Frames (chassis spaces ETC)
1x Fitting Kit Screws/Pipe Clips 8mm
1x 1.5m Filler hose
1x Sill Mounted Bayonet filler
1x LED switched gauge and sender
1x Stainless Steel Pigtail
1x Standard Remote Regulator
25ltr LPG Vapour Tank specifications:
Measurements – diameter 200mm x length 884mm
Tank weight empty – 16.8kg
LPG in litres @ 80% – 20ltr
LPG in kg @ 80% – 10kg